Which oil to use for transmission.

Hey guys.

Well i took out my gearbox and need to refill it now.

What oil are you guys using, A common brand and type would be awesome so i can whip down and buy some tonight.

Regards Vice

4 SPEED
VALVOLINE DURAGEAR 75W-85

Thanks man.. Ill get on it after work.

Cheers Vice

vicelore wrote:Hey guys.

Well i took out my gearbox and need to refill it now.

What oil are you guys using, A common brand and type would be awesome so i can whip down and buy some tonight.

Regards Vice

make sure You fill the gearbox slowly as the oil can back up and look like its full when its not....
mark on Your oil bottle how much oil needs to go in...
and make sure it all goes in...
until it starts to come out the filler hole then put the plug in fast.... lol

is that oil hypoid oil Ian?

Hypoid oil should be used as the differential is in the VW transaxle/gearbox...

75w/85 is a good oil weight...

LEE

Beetle box ???

Basically a good GL4 oil... Redline MTL 70W-80 is nice if you're feeling wealthy and the box is fresh, or for about half the $$$ something like Castrol Syntrans (75W-85 that's pretty similar spec and price to the Valvoline that Ian's said above).

If the box is a bit tired and cranky then maybe try going up to an 80W-90.

Kombi boxes from what I understand need an EP (hypoid) gear oil...

Its a 67 type 3 box.

Been out for a short axle conversion..

How much do you normally put in ? so i know how much to buy..

Cheers Vice

You need to buy 5 litre bottle...

You will need just under 3 litres of oil to fill Your gearbox transaxle..

You could buy 3 x 1 litre bottles but it will usually cost more than one 5 litre or 4 litre bottle...

cheers

LEE

75w/85 or 85 Hypoid transmission oil

that duramax may be Hypoid oil I don't know..

LEE

THanks man, So i need to make sure its Hypoid oil ?

I'm watching with interest while my trans oil drains....had 80/90 in it, which was the advice of the person that built it.

A little off topic, but I recently changed the trans oil in my suzuki swift. Put in 80/90 and it became harder to shift, especially when cold.

So, I drained it and put some castrol VMX 80 in (correct for that car) and it shifts like a hot knife through butter again.

Wondering if I should try it in the notch?

castrol VMX 80 is the only one to use.


hypoid gear diff oil ??

I used Castrol syntrans hypoid oil -= synthetic oil $$$$$$

in My gearbox and only bought 3 litres... 3 x 1 l bottles..

synthetic oil has a bad habit of leaking thru are bolt thread stud etc it can....

75W80 is good weight of oil...

LEE

Yep you need to have hypoid oil in your trans as Lee said.