| [ Total Views: 777 | Total Replies: 17 | Thread Id: 18619 ] |
|
|
 sand kombi
Officially Full-On Dubber
Posts: 345
Threads: 71
Registered: February 14th, 2003
Member Is Offline
Location: Logan Village[out skirts of Brisbane]
Theme: UltimaBB Pro Blue ( Default )
|
| posted on February 7th, 2004 at 05:50 AM |
|
|
SHELL OPTIMAX
Does anyone on the forum use Shell Optimax, the reason I am asking is I was doing a trial on it ( on recommendation) to see if the kombi runs any
better, and it does BUT I have found it is stuffing the seal on the fuel cap which now leaks, and now the fuel pump is leaking ? , coincedence or what
MIKE.
VW'S DON'T LEAK OIL, THEY JUST LEAVE THEIR MARK !!!
|
|
|
SteveMk2
Officially Full-On Dubber
Posts: 293
Threads: 27
Registered: November 5th, 2003
Member Is Offline
Location: Canberra
Theme: UltimaBB Pro Blue ( Default )
Mood: I always cruise flippantly...
|
| posted on February 7th, 2004 at 09:50 AM |
|
|
I think it could be coincidence, or the pump was only being held together by crud and the optimax cleaned it out. The seal could already have gone.
How old was the cap? Did petrol get on it directly?
I have only used Optimax in the GTI since I owned it, and while it is not aircooled (cannot vouch 100% for those engines)it was a UK model from 1985
and therefore leaded, and the fuel has improved the performance and increased the mileage. I have never had an issue with rubber seals and optimax.
Good luck an I hope this helps...
Steve. Classic 85 Mk2 2dr GTI 8v Optioned sunroof and 15"BBS RS alloys. Koni yellow and H&R, Balanced bottom end, flowed top end, Neuspeed
268 cam. |
|
|
Andy
Son of Jim - Creator of Good
Andy's Adventures
Posts: 2819
Threads: 181
Registered: November 5th, 2002
Member Is Offline
Location: Brisbane
Theme: UltimaBB Pro Blue ( Default )
Mood: Happy Man
|
| posted on February 7th, 2004 at 09:58 PM |
|
|
Likewise, I have used it for a while in Andy, and no leaks. Mind you everything (fuel line/fuel pump etc) are also fairly new.
:thumb
|
|
|
tassupervee
A.k.a.: Knob Jockey
Custom Title Time!
That really hurts doesnt it!
Posts: 1171
Threads: 25
Registered: September 21st, 2003
Member Is Offline
Location: Huon Valley SouthernTasmania
Theme: UltimaBB Psyche Blue
Mood: Moody!
|
| posted on February 7th, 2004 at 10:33 PM |
|
|
Did some testing a while back comparing Optimax with Pulp and we felt that the car (1200 F-Vee) did not perform nearly as well on the optimax.
As an aside, A given engine combination will produce higher horsepower on the lowest octane fuel it will tolerate.
I happily run plain old low octane ULP in the race car.
L8tr
E
Im not a complete idiot, quite a few parts are missing....
|
|
|
VDUBXTC
A.k.a.: Jace
Wolfsburg Elder
Tea Bag
Posts: 3587
Threads: 678
Registered: February 21st, 2003
Member Is Offline
Location: Somewhere on the South side Brissy QLD
Theme: UltimaBB Pro Navy
Mood: swept off my feet by an Ang3l
|
| posted on February 7th, 2004 at 11:00 PM |
|
|
Dudes.
Optimax is no good on any older cars using carbies.
I work for shell and after stuffing a bettle motor using optimax, i was told at a seminar that Optimax was no good to use on older motors on a regular
basis.
Make sure you use the valve master when using optimax.
If you are using it just for the octane rating ,just use the octane boost products out there with your regular fuel
|
|
|
 vanderaj
A.k.a.: Andrew van der Stock
Super Administrator
a suffusion of yellow
Posts: 3123
Threads: 438
Registered: August 26th, 2002
Member Is Offline
Location: Colorado Springs, CO, USA
Theme: UltimaBB Pro Yellow
Mood: In the family again
|
| posted on February 7th, 2004 at 11:33 PM |
|
|
Octane ratings has almost nothing to do with power output, heat output or anything like that.
A higher octane fuel will burn slower and more evenly than a low octane fuel.
Newer engines work better with higher octane fuels due to their combustion chamber design.
Engines with high compression ration (> 9.5:1) with ECUs and fuel injection can use high octane fuels and are likely to have fuel maps for the
higher octane fuel. Most Euro engines do not have a fuel map for 91 fuel and require a minimum of 95 fuel relatively low sulphur (< 100 ppm) fuel
(which is the minimum you can get over there). They use "limp home" mode when they experience too much pinking or unacceptable emissions
which is why for watercooled owners, you should stick with 95 or better fuel. These engines will feel slow or gutless using the "limp home"
mode.
Older engines with low compression ratios (say the 7 to 8:1 of most non-race non-aero aircooled engines) don't make use of these modern
techniques because they are retro tech (see pictures from the EPA Car Ecometer, relating to my two cars, with my driving habits and distance) and have
terrible emissions as a result. Therefore, as long as you don't pink or backfire on the lowest cost fuel you can afford, you can't hurt the
environment much more than about 30 odd new cars.
Optimax is a good fuel - it's low sulphur (50 ppm), has cleaning agents, and generally will make modern engines use a little less fuel and feel
peppier (certainly did on my previous three cars, haven't run my Cit on anything else yet).
The old "Super" was 96 RON, but if your engine can handle the normal 91 RON fuel without backfiring, go for it.
Andrew
|
|
|
tassupervee
A.k.a.: Knob Jockey
Custom Title Time!
That really hurts doesnt it!
Posts: 1171
Threads: 25
Registered: September 21st, 2003
Member Is Offline
Location: Huon Valley SouthernTasmania
Theme: UltimaBB Psyche Blue
Mood: Moody!
|
| posted on February 8th, 2004 at 01:27 PM |
|
|
| Quote: |
Octane ratings has almost nothing to do with power output, heat output or anything like that.
|
Errrr, thats not the case at all.
Unfortunately, I cannot find the documentation and dyno data to back up what I said.
This is particularly true on racing 2 strokes but is relevant to all engines when chasing the last word in inch/Lb's of tourque.
The lower octane rating of fuel in a given setup can be made to produce more power but often at the expense of grenading the engine as well so most
dudes just pour in the highes octane fuel thay can find to mask any tuning fuckups that would otherwise grenade the engine.
A dakdak has such low specific power output that they will just about run on anything that burns in stock form so chances of exploiting such increases
in HP are pretty slim but in a really high specific power output engine, such as my RS125 Honda that is in the vicinity of 340 BHP the gains are there
to be had.
I still claim that the F-Vee did not perform as well on Optimax as on Standard ULP.
Anyway, there you go.
L8tr
E
Im not a complete idiot, quite a few parts are missing....
|
|
|
Flying VW
Wolfsburg Wizard
Posts: 680
Threads: 32
Registered: August 30th, 2002
Member Is Offline
Location: Melbourne
Theme: UltimaBB Pro Blue ( Default )
Mood: Buzzing
|
| posted on February 8th, 2004 at 07:52 PM |
|
|
I use B.P ultimate in my Beetle and XR8.
Ultimate is simular to Optimax, anyway my Beetle seems to run the same wether it has LOW or HIGH Octane fuel.
But my XR8 seems to go about 5-10 % better on HIGH OCTANE. 
I saw a V8 2000 model Ford go on a Dyno, with a tank full of low Octane fuel and it PINGED it's guts out. |
|
|
KruizinKombi
A.k.a.: Col
Bishop of Volkswagenism
Seriously Obsessed Cyber Dubber
Posts: 3493
Threads: 104
Registered: August 25th, 2002
Member Is Offline
Location: Gippsland, Victoria
Theme: UltimaBB Pro Blue ( Default )
Mood: Indifferent
|
| posted on February 9th, 2004 at 07:40 AM |
|
|
I run Optimax in my 1800 kombi, because it noticably decreases pinging, allowing me to run a few degrees of extra advance.
I was running Optimax in the 1500 Beetle also, but Heather chooses to use standard ULP, so I've since timed it accordingly.
I'm not sure about the seals thingy, but I believe I get more oomph from PULP. :thumb
Kruizin Kol
|
|
|
toybug
A.k.a.: Dougie
Casual Dubber
Posts: 26
Threads: 9
Registered: December 2nd, 2002
Member Is Offline
Location: Pakenham
Theme: UltimaBB Pro Blue ( Default )
Mood: as always DAMM FINE
|
 posted on February 10th, 2004 at 03:17 PM |
|
|
OPTIMAX
Well at just over 92,000 MILES since putting TOYBUG together 4 years ago I have run with Optimax almost in every tank full
And for those who have cruised with me you know it goes
the differences is about 45 miles better per tank than ulp
so the cost is ruffly the same I had the heads of in Nov and they were spotless
have not found any seals to have perished (I have no cork seals)
In the Kombi it gives much better grunt than ulp
Dougie
|
|
|
vanderaj
A.k.a.: Andrew van der Stock
Super Administrator
a suffusion of yellow
Posts: 3123
Threads: 438
Registered: August 26th, 2002
Member Is Offline
Location: Colorado Springs, CO, USA
Theme: UltimaBB Pro Yellow
Mood: In the family again
|
| posted on February 10th, 2004 at 05:13 PM |
|
|
| Quote: | Originally
posted by tassupervee
| Quote: |
Octane ratings has almost nothing to do with power output, heat output or anything like that.
|
Errrr, thats not the case at all.
|
Errrr, yes, it is the case.
The higher the octane rating, the more resistant the fuel is to detonation / pinking and the slower it is to burn. 91 and 98 still produce the same
specific energy as output, just at different rates.
Please read here:
http://www.geocities.com/vwresource/octane.html
Modern engines use the properties of higher octane fuels to go for higher compression, and thus do more work with the fuel.
Dynocharts:
http://www.autospeed.com/cms/article.html?&A=0429
Unleaded / leaded article:
http://www.autospeed.com/cms/A_870/article.html
Please Google before correcting me.
Andrew
|
|
|
tassupervee
A.k.a.: Knob Jockey
Custom Title Time!
That really hurts doesnt it!
Posts: 1171
Threads: 25
Registered: September 21st, 2003
Member Is Offline
Location: Huon Valley SouthernTasmania
Theme: UltimaBB Psyche Blue
Mood: Moody!
|
| posted on February 10th, 2004 at 06:51 PM |
|
|
Dooood!
I know what I know.
As a former fuels and lubricants rep for a Caltex, I have good access to the fuels info I need.
Furthermore, I have been building, racing and tuning HiPo 2 stroke road race engines for nearly 20 years.
I can tell you that for a GIVEN setup, it CAN be made to produce MORE hp on the lowest octane rated fuel the given setup will cope with but at the
expense of grenading unless EVERYTHING is absolutely correct.
CMS performance in melbourne are noted Honda GB Bike 2 stroke tuners and their title winning RS125 Hondas are producing the most hp they have seen on
plain old pump ULP! This is the vicinity of 380 BHP/Litre.
Because they can!
They dont bother with high octane jungle juices and boutique race fuels. Pump ULP, however, and this is a bit however, they stress the propensity of
the engines to grenade.
I dont think you are quite getting the point of my post.
Oh well.
Pity I cannot find my data and sources.
You loose that stuff when puters die!!!!! Phttt!
L8tr dude
E
Im not a complete idiot, quite a few parts are missing....
|
|
|
VDUBXTC
A.k.a.: Jace
Wolfsburg Elder
Tea Bag
Posts: 3587
Threads: 678
Registered: February 21st, 2003
Member Is Offline
Location: Somewhere on the South side Brissy QLD
Theme: UltimaBB Pro Navy
Mood: swept off my feet by an Ang3l
|
| posted on February 10th, 2004 at 11:33 PM |
|
|
Guys this might raise a few eyebrows.
In NSW their has been 9 proven cases and another 23 current court cases to do with optimax against shell australia .
All cases are engine damage related.
Not all high millage old cars either.
one case is a 03 subaru wrx with 11,624kms on it .
If your going to use a high oct fuel go the BP Ultimate
|
|
|
REDKG
Officially Full-On Dubber
Posts: 327
Threads: 76
Registered: August 29th, 2002
Member Is Offline
Location: sutherland-sydney
Theme: UltimaBB Pro Blue ( Default )
|
| posted on February 11th, 2004 at 06:59 AM |
|
|
my 2 cents worth. i run ulp in both my fastback and KG , both set to 32 degrees advance with no problem. in the 1800 kombi with hi comp heads i need
to run pulp but usually use caltex pulp since it is about 5 cents a litre cheaper than BP or Shell .
|
|
|
tassupervee
A.k.a.: Knob Jockey
Custom Title Time!
That really hurts doesnt it!
Posts: 1171
Threads: 25
Registered: September 21st, 2003
Member Is Offline
Location: Huon Valley SouthernTasmania
Theme: UltimaBB Psyche Blue
Mood: Moody!
|
| posted on February 12th, 2004 at 08:34 PM |
|
|
Hey 0064
Whats the gist of their claims dude?
L8tr
E
Im not a complete idiot, quite a few parts are missing....
|
|
|
VDUBXTC
A.k.a.: Jace
Wolfsburg Elder
Tea Bag
Posts: 3587
Threads: 678
Registered: February 21st, 2003
Member Is Offline
Location: Somewhere on the South side Brissy QLD
Theme: UltimaBB Pro Navy
Mood: swept off my feet by an Ang3l
|
| posted on February 12th, 2004 at 11:09 PM |
|
|
ya got U2U Tassupervee
|
|
|
VWCOOL
23 Windows of Awesome
Posts: 5158
Threads: 235
Registered: June 19th, 2003
Member Is Offline
Location: In the shed... Lake Macquarie NSW
Theme: UltimaBB Pro Blue ( Default )
Mood: happy to help
|
| posted on February 13th, 2004 at 09:01 AM |
|
|
My ECU'd knock-sensored car pings like **** on Opticrap, but kicks butt on BP Ultimate. I don't think Optimax is as good a brew as it was
when launched. As for using it in air cooleds, I don't know!
Pay your debts, CxxT
|
|
|
Midlife crisis
Veteran Volks Folk
Nartispuddlejumper, Bureau of Toxicity
Posts: 2282
Threads: 160
Registered: May 17th, 2003
Member Is Offline
Location: Logan city south of Brisbane
Theme: UltimaBB Pro Blue ( Default )
Mood: Wornout and Toxic
|
| posted on February 13th, 2004 at 03:23 PM |
|
|
I tried optimax on the weekend just to see what it was like
have to say I agree with VWcool mine pinged is heads off when tanks was nearly empty ( eedle hanging of guage) filled with Bp ultimate and the pings
are gone going to stay with BP ultimate thats for my car each car and setup is different
Marc
If you can't laugh at yourself you can't laugh at anyone else! Because life is to short not to LAUGH
|
|
|
Craig Torrens
A.k.a.: Craig Torrens
Scirocco Rare
6 times Australian, 7 times State Hillclimb Class Champion
Posts: 8040
Threads: 347
Registered: January 10th, 2003
Member Is Offline
Location: Sydney
Theme: UltimaBB Pro Blue ( Default )
Mood: Time to go Salt lake racing, and actually achieve a result.
|
| posted on February 13th, 2004 at 04:47 PM |
|
|
well I use optimax in the bug and it seems OK :thumb. Have not tried BP ultimate so I can not compare.
Not as cool running as BP100, about 5-10 deg C diff, on the track. But then you can't buy bp100 or Avgas from the local servo either unless you want to pay $50 for a 20lt drum!!!
|
|
|
tassupervee
A.k.a.: Knob Jockey
Custom Title Time!
That really hurts doesnt it!
Posts: 1171
Threads: 25
Registered: September 21st, 2003
Member Is Offline
Location: Huon Valley SouthernTasmania
Theme: UltimaBB Psyche Blue
Mood: Moody!
|
| posted on February 13th, 2004 at 09:40 PM |
|
|
Nope and you cant buy it without a Govt. passbook now.
Fines for running the stuff in a vehicle not in motorsport start at (from memory) $50,000 bucks for an individual and a lot more for companies.
Furthermore, you wont ever be able to buy leaded Avgas after March 2005
Have fun!
L8tr
E
Im not a complete idiot, quite a few parts are missing....
|
|
|
