| [ Total Views: 453 | Total Replies: 3 | Thread Id: 93957 ] |
|
|
 mjwcookie
Seriously Crusin Dubber
Posts: 105
Threads: 57
Registered: March 21st, 2011
Member Is Offline
Location: Point Lonsdale, Vic
Theme: UltimaBB Pro Blue ( Default )
|
| posted on November 22nd, 2011 at 11:17 PM |
|
|
electrical short
hi all. I have some questions. i had a short the other night in behind the speedo. there was a wire soldered between the dash light dimmer and the
power to the headlights. It has been there for as long as i have had the car and never any trouble. well it shorted and burned out. so i replaced it
and it did it again. i then left the wires seperate and all seems to work ok. can anyone tell me why it was there in the first place, it was not done
professionally nor is original.
2nd. my speedo has stopped working continually. the speed needle works ok, but the distance counter starts and stops. how can i fix this.
3rd. On the dash is the aircon switches, there are the two dials (fan and Temp) and two on/off switches. THe left one seems to be for a fan booster,
but what is the right one for?
4th. The aircon compressor does not work when i switch on the dial. that is to say the compressor clutch does not engage to drive the compressor.
where are the fuses for it to check?
Thanks for any help i getting this sorted.
Mark
Mark Wilson
78 bay window, 82 bay Westy. T3 Caravelle GL 89 on the road.
Now in Victoria.
|
|
|
blutopless2
Veteran Volks Folk
DAMSLO
Posts: 2457
Threads: 187
Registered: January 8th, 2004
Member Is Offline
Location: melbourne
Theme: UltimaBB Pro Blue
|
| posted on November 23rd, 2011 at 07:10 AM |
|
|
the speedo issue will most likely be one of the gears that drive the odometer wheels - pinion gear usually cracks under full load. Other possibility
is that the wheels are not located on the shaft correctly so dont make proper contact with their teeth to one another.
Have to pull it apart to check all the gears and wheels etc..
see.... air and water do mix 
1974 1300
1997 MK3 Golf GL
2003 NB Cabrio
2012 Golf VI GTI
2014 Audi A4 Quattro |
|
|
Joel
Scirocco Rare
Now containing 100% E-Wang
Posts: 9368
Threads: 211
Registered: February 14th, 2006
Member Is Offline
Location: Northern Rivers NSW
Theme: UltimaBB Pro Purple
Mood: Tact Level 0.00
|
| posted on November 23rd, 2011 at 11:47 AM |
|
|
It may have been a bypass on the headlight switch around the rheostat to keep the dash lights going, they burn out often and the dash lights dont
work.
THey are also unfused too so any short melts wiring cos there is no fuse to blow.....well done VW!
If the A/C hasn't worked since you got the car it will be low on charge and the LP safety switch is stopping the compressor running.
Automotive A/C loses it gas charge if they go for long periods without being used as the compressor shaft seal drys out and the gas escapes.
Thats why the manuals tell you run the A/C atleast monthly even through winter to keep the seals oiled.
|
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on November 23rd, 2011 at 02:05 PM |
|
|
| Quote: | Originally
posted by blutopless2
the speedo issue will most likely be one of the gears that drive the odometer wheels - pinion gear usually cracks under full load. Other possibility
is that the wheels are not located on the shaft correctly so dont make proper contact with their teeth to one another.
Have to pull it apart to check all the gears and wheels etc..
|
I had a beetle one that the gear used to move away from the pinion gear... so wouldn't drive... just moved the bracket slightly
sometimes the gears actually come apart so would need replacing
LEE
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
