| [ Total Views: 720 | Total Replies: 11 | Thread Id: 103411 ] |
|
|
 strex
Seriously Crusin Dubber
Posts: 145
Threads: 57
Registered: August 27th, 2002
Member Is Offline
Location: Epping- Sydney
Theme: UltimaBB Pro Blue ( Default )
Mood: Time Flies
|
| posted on September 9th, 2013 at 10:05 PM |
|
|
My Notch won't start..Can you help?
Notchback 1964 still 6 volts...
So although I don't drive it much it usually starts first go but I am in a bind and cannot get it to kick .. I was hoping that you may be able to
give me some advice.
Here's the current status.. Normally to start I remove the air filter and squirt some Aerostart down the carby, pump the gas and it fires. But no
go.
I have a spark at the points albeit no so bright but it could be the 6v .. Never looked before. The battery is on a recycling charger so it is healthy
and has plenty of juice to turn over .. I put some new petrol in in case it was dry.Fuel gauge does not work.. There is petrol in the fuel filter... I
have had to replace the fuel previously as it went off but it usually fires albeit like crap until new fuel goes in... I'm thinking it is electrical
as the Aerostart would have ignited if it was not.. Is it possible the coil may have died.. How would you know? There is also some type of relay near
the coli..could this have died?
Surely it can't be much .. Any advice would be appreciated.
Cheers
Lex
Go Noddy the Notch ~ One day the Oval will ride again
|
|
|
dragsters for life
Fahrvergnugen
Posts: 953
Threads: 51
Registered: May 28th, 2011
Member Is Offline
Location: melburg SE burbs
Theme: UltimaBB Pro Blue ( Default )
Mood: always a happy chappy
|
| posted on September 9th, 2013 at 10:25 PM |
|
|
coil is a start just check everything one at a time, you never know the battery could be shot as it does happen
volkaholics.net come check us out
|
|
|
vwo60
Veteran Volks Folk
Posts: 2036
Threads: 71
Registered: February 13th, 2007
Member Is Offline
Location: Pomona Qld
Theme: UltimaBB Psyche Blue
Mood: good
|
| posted on September 9th, 2013 at 10:32 PM |
|
|
Try the condensor on the side of the distributor, i have had this happen to me years ago,
|
|
|
beetle_nut
Wolfsburg Wizard
Posts: 465
Threads: 55
Registered: January 22nd, 2012
Member Is Offline
Location: brisbane
Theme: UltimaBB Pro Blue
Mood: rollin low n rollin slow.65 notch back and 59 beetle
|
| posted on September 10th, 2013 at 12:13 PM |
|
|
Try the points i had the same problem on a kombi.cleaned them up and away she went.
|
|
|
empi
A.k.a.: Empstar
Compulsive Aussie Vee Dubber
Posts: 4131
Threads: 178
Registered: August 27th, 2002
Member Is Offline
Location: melbourne
Theme: UltimaBB Pro Blue ( Default )
Mood: thunderous
|
| posted on September 10th, 2013 at 12:18 PM |
|
|
Coil points (Gap) or condensor
check it has fuel and that fuel is going to carbs
"If at first you don't succeed, skydiving is not for you." - Anonymous  |
|
|
greedy53
Bishop of Volkswagenism
Posts: 3062
Threads: 468
Registered: March 4th, 2006
Member Is Offline
Location: camden nsw 2570
Theme: UltimaBB Pro Grey
Mood: strung out
|
| posted on September 10th, 2013 at 08:36 PM |
|
|
try starting at night and get someone to watch and see if there is any spark were there sould not be spark
|
|
|
strex
Seriously Crusin Dubber
Posts: 145
Threads: 57
Registered: August 27th, 2002
Member Is Offline
Location: Epping- Sydney
Theme: UltimaBB Pro Blue ( Default )
Mood: Time Flies
|
 posted on September 15th, 2013 at 09:32 PM |
|
|
Guys,
Thanks for the advice ... But I am still no better off.
So today I tested the coil - HT from coil to ground = healthy spark.
Spark at the points = Yes
Pulled out a spark plug, held it to ground = Decent spark
Tells me the ignition/electrical system is working ..
Next drained all the petrol (I hate that job) on the assumption that the fuel was off .. Replaced it still no go.
Disconnected fuel line to carby = Fuel pump works as petrol squirts out.
Again Aerostart into the carby and nothing..
Motor turns over but no hint of anything firing.
If the condensor was broken, would there still be a spark? Should I try replacing the condensor?
I really am beat .. I cannot for the life of me figure out what the problem could be ..
Any more ideas would definitely be appreciated..
Thanks in advance
Go Noddy the Notch ~ One day the Oval will ride again
|
|
|
donn
Wolfsburg Elder
Posts: 3515
Threads: 428
Registered: November 30th, 2005
Member Is Offline
Location: NEWCASTLE NSW
Theme: UltimaBB Pro Blue
Mood: LAID BACK AND CONFUSED
|
| posted on September 15th, 2013 at 10:47 PM |
|
|
Fuel + spark = should go unless the timing is out ........maybe
I dream of a day when a chicken can cross a road without being asked for it's motive!
|
|
|
bitemeoz
Officially Full-On Dubber
Posts: 355
Threads: 38
Registered: October 13th, 2003
Member Is Offline
Location: The Hills, Sydney
Theme: UltimaBB Vintage
Mood: Antsy
|
| posted on September 15th, 2013 at 11:58 PM |
|
|
check your points. it wont start if they are way out.
|
|
|
beetleboyjeff
A.k.a.: Jeff Walsh
Custom Title Time!
Posts: 1773
Threads: 40
Registered: February 13th, 2009
Member Is Online
Location: Port Macquarie
Theme: UltimaBB Pro Blue ( Default )
Mood: Drive bugs hard
|
| posted on September 16th, 2013 at 12:32 AM |
|
|
I would suggest a timing problem.
From your ole' mate Jeff
|
|
|
greedy53
Bishop of Volkswagenism
Posts: 3062
Threads: 468
Registered: March 4th, 2006
Member Is Offline
Location: camden nsw 2570
Theme: UltimaBB Pro Grey
Mood: strung out
|
| posted on September 20th, 2013 at 09:54 PM |
|
|
sounds like points are closed no gap
|
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on September 21st, 2013 at 12:17 AM |
|
|
Hi
I sent You a PM.. I was in EPPING on the 10th.. lol
but just coming home from Adelaide..
If You have fuel and air.. then it has to be SPARK...
6 volts doesn't have much in reserve when the starter motor is turning.. this all gets worse over the years as all the connections get contaminated
and earthing etc all gets worse..
try running a wire to the coil from the battery ++ for a good 6 volts ignition... as Your ignition switch would be
a coil can work intermittantly ...
You cannot really tell anything by the spark in the points...
that is just telling You the condensor is working... just how good though...?? pull all the connectors off and put back on a few times.. one wire
at a time... on the coil etc..
to help clean them up.. .
make sure the engine is turning over fast...
can't remember how fast they went on 6 volts.. lol
but after all these years the voltage drop would be terrible..
cheers
LEE
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
