| [ Total Views: 486 | Total Replies: 10 | Thread Id: 19773 ] |
|
|
 vdbleu2002
Seriously Crusin Dubber
Posts: 154
Threads: 40
Registered: September 3rd, 2002
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
|
| posted on March 3rd, 2004 at 05:17 PM |
|
|
door pops open on bumps on 60's bug
Is there an adjustment or worn parts to be replaced to rectify this. Any advise would be greatly appreciated.
|
|
|
nicko
Officially Full-On Dubber
Posts: 389
Threads: 77
Registered: March 18th, 2003
Member Is Offline
Location: Mid North Coast(Blackhead)
Theme: UltimaBB Pro Blue ( Default )
Mood: Tired
|
| posted on March 3rd, 2004 at 05:36 PM |
|
|
doors opening
You should check the hinge pins to see if they are loose. Open the door and grab the outside edge and see if it rocks up and down. If it does they may
need replacing. This was the problem with my old 66 bug. It also did not help that the car was lowered which made the bumps a lot harder than a stock
suspension would. You should get some one who knows what they are doing to check and change pins if neccessary
Nicko
|
|
|
Oasis
Custom Title Time!
Going alone...
Posts: 1806
Threads: 77
Registered: July 5th, 2003
Member Is Offline
Location: Cammeray, Sydney
Theme: UltimaBB Pro Blue ( Default )
Mood: Deep
|
| posted on March 3rd, 2004 at 05:49 PM |
|
|
Mine used to pop open all the time. I thought they all did to a degree? Worn striker plate I think, or the pins as nicko suggested
"Tell him 'We've already got one'"
|
|
|
pod
A.k.a.: paul mrvw061
Compulsive Aussie Vee Dubber
i`ve got to finish this thing one day
Posts: 4980
Threads: 145
Registered: December 28th, 2003
Member Is Offline
Location: campbelltown,nsw
Theme: UltimaBB Pro Yellow
Mood: could be better
|
| posted on March 3rd, 2004 at 05:51 PM |
|
|
I`d say most likely worn striker plate or badly adjusted
|
|
|
VWFOOL
Bishop of Volkswagenism
King for a day, Fool for a lifetime.
Posts: 3436
Threads: 572
Registered: September 3rd, 2002
Member Is Offline
Location: Newcastle - Sydney
Theme: UltimaBB Pro Blue ( Default )
Mood: inspired yet?
|
| posted on March 3rd, 2004 at 06:28 PM |
|
|
if u hav rust in the a pillars down the bottom could this affect the doors shutting properly. ive seen the doors continue to pop open even after
striker plates hav been replaced wen there is rust in the channels. wat do u think?
++++++++++++++++++++++++++++
One man's junk...
|
|
|
BettyBoop
Wolfsburg Wizard
Posts: 460
Threads: 35
Registered: November 8th, 2003
Member Is Offline
Location: Sunny Coast: Caloundra
Theme: UltimaBB Pro Blue ( Default )
Mood: Boop-Oop-a-Doop
|
| posted on March 3rd, 2004 at 07:16 PM |
|
|
ROFL!!!!
All i can say is... U2U a guy on forum here called Skyhawk or Liam... he'll tell ya ALL BOUT IT ... he's bin gettin his bug
"grimace" to try n stop doin that exact same thing...
ciao
Kat
|
|
|
555bug
Custom Title Time!
WRX Bug Boy
Posts: 1123
Threads: 79
Registered: August 26th, 2002
Member Is Offline
Location: Brisbane
Theme: UltimaBB Vintage
Mood: turbo charged
|
| posted on March 3rd, 2004 at 08:19 PM |
|
|
replace the rubber on the front beam-to-body. When worne they also contribute to this. |
|
|
jnr356
Wolfsburg Wizard
Posts: 603
Threads: 33
Registered: January 17th, 2004
Member Is Offline
Location: Ost melburg
Theme: UltimaBB Pro Blue ( Default )
Mood: casual
|
| posted on March 3rd, 2004 at 09:27 PM |
|
|
usually the striker plate is worn,but have also had dodgy door lock mechanisms do this as well.
|
|
|
ByronBug
Custom Title Time!
High Priestess of Unequaled Coolness & Flower Child
Posts: 1446
Threads: 150
Registered: September 24th, 2002
Member Is Offline
Location: Byron Bay NSW
Theme: UltimaBB Pro Purple
Mood: Bent
|
| posted on March 3rd, 2004 at 09:40 PM |
|
|
:sandrine
Most people have suggested it may be your striker plates...so check them first.
I had the same problem a little while ago with my drivers side door....
These get worn out & is the most common problem, so replace them first, then if this is still happening, follow everyone else's
suggestions
Judy
59 Microbus Kombi (MERCY)
64 Microbus Kombi (CHANNON)
 |
|
|
Canni.
Wolfsburg Wizard
Posts: 471
Threads: 29
Registered: September 21st, 2003
Member Is Offline
Location: Melbourne
Theme: UltimaBB Pro Blue ( Default )
|
| posted on March 4th, 2004 at 05:38 PM |
|
|
Mine started popping open once I had new door rubber seals put on  not only
do they pop open on bumps but also sometimes when turning....hehehe and the best...close one door and the other one pops open 
Heidi - 1960 White Beetle
'65 Kiwi Ghia
|
|
|
Che Castro
Custom Title Time!
ankle straps
Posts: 1945
Threads: 79
Registered: August 25th, 2002
Member Is Offline
Location: Sydney, Australia
Theme: UltimaBB Pro Blue ( Default )
Mood: (( }:-{D]
|
| posted on March 4th, 2004 at 10:26 PM |
|
|
yeah my 63 does this. Its pretty common on the older bugs.
Mine only happens on the drivers side, i replaced the striker plate, although it still opens, it has been adjusted to the manual spec. The latch bit
on the actual door wears out too. My hinges are pretty old too.
the design is pretty crap compared to the late bug design, the late bug design is like a modern car, it cant accidentally bust open to the safety
catch
Jon
|
|
|
Oasis
Custom Title Time!
Going alone...
Posts: 1806
Threads: 77
Registered: July 5th, 2003
Member Is Offline
Location: Cammeray, Sydney
Theme: UltimaBB Pro Blue ( Default )
Mood: Deep
|
| posted on March 4th, 2004 at 11:53 PM |
|
|
Out of curiosity, can you put later model doors on older bugs? or even just the plates?
"Tell him 'We've already got one'"
|
|
|
Sky
Officially Full-On Dubber
Posts: 251
Threads: 43
Registered: September 4th, 2003
Member Is Offline
Location: Brisbane
Theme: UltimaBB Pro Blue ( Default )
|
| posted on March 28th, 2004 at 10:32 PM |
|
|
Hihi Finally I see a post I have a bit on info on 
Could be many things, With grimace it was that there was a repair and full of bog, you would drive along or go around corners and bang the door flew
open, job was about $300 to fix and now there is welded metal, doors now close.
Try opening the door and lifting it up, look at the hinges see if there is play there
|
|
|
