| [ Total Views: 607 | Total Replies: 0 | Thread Id: 4653 ] |
|
|
 Purple Martin
A.k.a.: Martin
Fahrvergnugen
Posts: 913
Threads: 141
Registered: February 13th, 2003
Member Is Offline
Location: Canberra
Theme: UltimaBB Pro Blue ( Default )
Mood: warm & fuzzy
|
| posted on March 24th, 2003 at 09:42 AM |
|
|
Heater smells
Hi everyone,
I get strong "hot" smells through my heater. It smells like an engine that is at running temp (you know, kind of oily), and the smell
starts very soon after starting the engine (about 30 seconds). Is it likely to be a problem inside the heat exchangers?
TIA
1959 red & white Beetle
1975 Kombi camper
|
|
|
 Bizarre
Super Moderator
The artist formerly known as blue74l
Posts: 12780
Threads: 734
Registered: August 25th, 2002
Member Is Offline
Location: Abbotsford, Sydney
Theme: UltimaBB Pro Blue ( Default )
|
| posted on March 24th, 2003 at 10:49 AM |
|
|
You have a Kombi dont you?
It will be either (i think) oil that has leaked from a valve cover on to the heater box - this will apply for either T1 or T2
or
If a T2 isnt there a heater box gasket on the exhaust? that can sometines leak.
Does ot backfire at all?
If not and definetiley oily smell - check for a leaking rocker cover
Futue te ipsum!!!
|
|
|
Purple Martin
A.k.a.: Martin
Fahrvergnugen
Posts: 913
Threads: 141
Registered: February 13th, 2003
Member Is Offline
Location: Canberra
Theme: UltimaBB Pro Blue ( Default )
Mood: warm & fuzzy
|
| posted on March 24th, 2003 at 11:32 AM |
|
|
Yeah it's a kombi (doh I should have mentioned that). It doesn't back fire at all, it runs quite well. I guess I need to look for oil
leaks. I know there are lots, I just have to decide which ones I can ignore and which ones are important. :-S
1959 red & white Beetle
1975 Kombi camper
|
|
|
Andy
Son of Jim - Creator of Good
Andy's Adventures
Posts: 2818
Threads: 181
Registered: November 5th, 2002
Member Is Offline
Location: Brisbane
Theme: UltimaBB Pro Blue ( Default )
Mood: Happy Man
|
| posted on March 24th, 2003 at 12:03 PM |
|
|
Smelly hot air in a VW is always a problem with a lot of things contributing. Especially on a Kombi. The air for the heater is sucked from the engine
bay, so any oil/dirt/fuel in there gets sucked through by the fan, so give it a good clean and check for any leaks, especially the engine to body
seal! (Always a good idea). Secondly as Blue74L said any oil leaking from pushrod tubes or tappet cover goes straight onto the heat exchangers, so if
the oil gets inside the exchangers it too will pollute the heated air. Lastly if all the pipes are old or even original there is many years of dirt
and grim built up inside of them which again gets smelly as it heats up.
All that done, I have my system all pretty clean and well sealed, but it’s still a little smelly. I don’t mind it (acquired taste!!!) as I know
there’s no oil or exhaust fumes in there, but new passengers often complain.
|
|
|
Phil74Camper
Son of Jim - Creator of Good
Head in the Clouds
Posts: 2703
Threads: 193
Registered: August 28th, 2002
Member Is Offline
Location: Sydney
Theme: UltimaBB Pro Blue ( Default )
|
| posted on March 24th, 2003 at 12:06 PM |
|
|
Give the engine undersides a good degrease and hose-down - a hoist is best for this but otherwise get in and under with the hose as best you can. Then
a few days later it's easier to see where any oil leaks are coming from.
VW heaters always have some degree of enginey smell about them, even when the heater boxes are new or freshly painted. Even if there are no leaks at
all, the air still comes from the inside of the engine bay. Leaking or rusty heater boxes might be a source of carbon monoxide, which can be
dangerous. A workshop can test that for you. Otherwise, you learn to live with the smell, it's part of the joys of owning an air-cooled
Volkswagen.
|
|
|
