| [ Total Views: 5835 | Total Replies: 15 | Thread Id: 50472 ] |
|
|
 glint
Learner Dubber
Posts: 2
Threads: 1
Registered: April 1st, 2006
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
|
 posted on April 1st, 2006 at 06:47 PM |
|
|
runs for 10 minutes then won't start for 1/2 hour
Hi
got a problem with my '69 beetle. she's a 1500 fairly standard bug as far as i can tell. had it for 3 years.
history: i smell fuel and pull over. the hose from the fuel pump is split and has been squirting fuel all over the place. luckily i had a piece of
old tubing - replaced and on my way.
later that week, engine starts to backfire and fade then stop [middle of traffic victroria road OF COURSE] wont restart. after 1/2 hour or so starts
again and i limp home. Get new fuel tubing and filter. hope for the best.
Lets me down again about 10 minutes into a drive to smithfield..remove carby top plate by the roadside and check fuel shutoff valve, big piece of
cottony crud - obviously from failed fuel tube Ah-HAH! put it all back together and on my merry way [back home of course...don't trust her now]
all is fine for a week [to and fro work- about 5 mins. drive]
then had to go to avalon, about 10 mins. into drive bang-bang fade-fade etc. bastard stops again.same story - limp home. so,get new coil [seen thisone before -coil gets hot and fails..] run engine for 1/2 hour at high idle in backyard- all seems good so, test run, about 10 minutes into test -the
rotten sl*t does it again.
Alright then, new points,condenser, carby kit. Do the buisness and test seems ok [backyard 3/4 hour various revs - neighbours real agro] road
test.
we'll i'll be jiggered if it doesn't fail again - fade in power the odd backfire then stop!
I'm stumped got one slightly noisy tappet [#3] other than that from cold it runs nice...up until it gets warm. any ideas?
cheers |
|
|
REDKG
Officially Full-On Dubber
Posts: 325
Threads: 76
Registered: August 29th, 2002
Member Is Offline
Location: sutherland-sydney
Theme: UltimaBB Pro Blue ( Default )
|
| posted on April 1st, 2006 at 07:01 PM |
|
|
sounds like a fuel problem. either a partial blockage or dirty fuel ie: water. did you clean the fuel pump also flush the tank and fuel line. l
|
|
|
koolkarmakombi
Veteran Volks Folk
enkarmarising
Posts: 2078
Threads: 158
Registered: June 16th, 2003
Member Is Offline
Location: viva brisvegas
Theme: UltimaBB Pro Blue ( Default )
Mood: do you see the bats?
|
| posted on April 1st, 2006 at 07:03 PM |
|
|
do a cold and hot compression test.
Pull the plugs hot and see what they look like.
Double check the valve adjustments.
when it wont start, check fuel, spark, engine bay wiring etc.
ahything modded in the engine bay? like ANYTHIG, a rewire through an ungrommeted metal connection???????
CAN be something w-e-i-r-d that often is obvious in hindsight.
kkk
This disclaimer does not reflect the thoughts or opinions of either myself, my company, my friends, or my dog: don't quote me on that; don't
quote me on anything; this disclaimer is subject to change without notice; text is slightly enlarged to show detail; resemblance to actual persons,
living or dead, is unintentional and coincidental; dry clean only; do not bend, fold, or mutilate; anchovies or jalapenos added to this disclaimer
upon request; your mileage may vary; no substitutions are allowed; for a limited time only while supplies last; offer void where prohibited; this
disclaimer is provided "as is" without any warranties expressed or implied
|
|
|
glint
Learner Dubber
Posts: 2
Threads: 1
Registered: April 1st, 2006
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
|
| posted on April 2nd, 2006 at 09:40 AM |
|
|
Thanks for your replies.
plugs were replaced and so were leads. a quick look at #4 plug yesterday showed it to be good [not wet].
engine bay wiring all good. when it wont start i have a good spark,fuel filter 3/4 full.
put another solex30-2 on yesterday [one with an ECV]. runs smooth...until it gets hot.then same problem.
will look at valves today...
cheers |
|
|
koolkarmakombi
Veteran Volks Folk
enkarmarising
Posts: 2078
Threads: 158
Registered: June 16th, 2003
Member Is Offline
Location: viva brisvegas
Theme: UltimaBB Pro Blue ( Default )
Mood: do you see the bats?
|
| posted on April 3rd, 2006 at 01:38 PM |
|
|
progress?
This disclaimer does not reflect the thoughts or opinions of either myself, my company, my friends, or my dog: don't quote me on that; don't
quote me on anything; this disclaimer is subject to change without notice; text is slightly enlarged to show detail; resemblance to actual persons,
living or dead, is unintentional and coincidental; dry clean only; do not bend, fold, or mutilate; anchovies or jalapenos added to this disclaimer
upon request; your mileage may vary; no substitutions are allowed; for a limited time only while supplies last; offer void where prohibited; this
disclaimer is provided "as is" without any warranties expressed or implied
|
|
|
Volkswagenboy
A.k.a.: Brenton Barry
Veteran Volks Folk
Staggers Automotive.
Posts: 2437
Threads: 92
Registered: July 28th, 2005
Member Is Offline
Location: Boronia Heights, Brisbane.
Theme: UltimaBB Pro Blue ( Default )
Mood: Indifferent
|
| posted on April 5th, 2006 at 08:40 PM |
|
|
Could it be a vapour lock problem?
-Staggers.
STAGGERS AUTOMOTIVE - Heavy Vehicle Diesel Specialist
JB CUSTOMS & CLASSICS - Car Builders
2/53 Tradelink Drive, Browns Plains |
|
|
aussiebaja
Insano Dub Head
Posts: 738
Threads: 98
Registered: June 13th, 2006
Member Is Offline
Location: bendemeer
Theme: UltimaBB Pro Blue ( Default )
Mood: happy
|
| posted on June 13th, 2006 at 07:23 PM |
|
|
hi sounds too me like its your coil getting hot then breaking down ,once it cools it starts and runs again until it gets hot then breaks down again |
|
|
MickH
A.k.a.: Michael Hutchinson
Bishop of Volkswagenism
Hairy Gutted Sloth
Posts: 3389
Threads: 29
Registered: September 6th, 2003
Member Is Offline
Location: TownsvilleTropical North QLD
Theme: UltimaBB Pro Blue ( Default )
Mood: Grow a brain...walls don't hit back...
|
| posted on June 13th, 2006 at 08:11 PM |
|
|
Fuel tank blockage?? If you've already replaced the coil as per stacy b,try and blow fuel back to the tank after engine has stopped (with fuel cap
off).If there is a lot of pressure/effort to blow back it might be blocking.
tssnq.com.au
|
|
|
beerdoc
A.k.a.: Doc
Insano Dub Head
Posts: 838
Threads: 42
Registered: July 27th, 2004
Member Is Offline
Location: Geelong Vic
Theme: UltimaBB Pro Blue ( Default )
Mood: Its all good
|
| posted on June 13th, 2006 at 09:31 PM |
|
|
Look for fuel filter where you think there would not be one
Sorry thats my humor or attempted of
What I mean is check all fuel lines for filter ie under tank,next to gearbox and replace
I have same problem with 75L
Did what Mick H suggested and if it happens again will have to remove tank I think
Cheers Doc
reVOLKS at Fyansford Geelong
20th OCT 2007 STAY TUNED FOR DETAILS
 |
|
|
Iwish4aSynchro
Wolfsburg Wizard
Posts: 639
Threads: 102
Registered: August 7th, 2006
Member Is Offline
Location: Maclean NSW
Theme: UltimaBB Pro Blue ( Default )
Mood: Cheery
|
| posted on September 10th, 2006 at 10:49 PM |
|
|
Dont know if this helps and may be totally unrelated but, I had this zxr250a jap road racer and it would do the same thing; meaninig the symptons are
exactly the same yes different vehicles and all that but they both have fuel and spark, right. After many a dollar spent on sourcing the prob it
turned out to be tht jets in the carbs. Jets were too small by a nats hair. Replaced jets on all four carbs and never had the prob again. If it helps
great if already done sorry for lateness.
Keep the steering and the propulsion seperate . Still a Kombi...
It's all good, until it's bad, i suppose
|
|
|
greedy53
Bishop of Volkswagenism
Posts: 3062
Threads: 468
Registered: March 4th, 2006
Member Is Offline
Location: camden nsw 2570
Theme: UltimaBB Pro Grey
Mood: strung out
|
| posted on May 29th, 2008 at 08:19 PM |
|
|
i had this problem a few years ago very similar for me it was a coil breaking down when hot stop wait until it cooled and away again
hope that helps
|
|
|
squizy
A.k.a.: Paul
Compulsive Aussie Vee Dubber
Thinking about another dub...maybe
Posts: 4082
Threads: 243
Registered: December 17th, 2002
Member Is Offline
Location: Thornleigh
Theme: UltimaBB Pro Blue
|
| posted on May 29th, 2008 at 08:45 PM |
|
|
| Quote: | Originally
posted by Volkswagenboy
Could it be a vapour lock problem?
-Staggers.
|
I reckon this too. Check where your fuel line is running and see if it's sitting across your risers or manifold, and move it away if it is. It could
be reaching a certain temperature, and then causing a vapour lock.
|
|
|
Adsman
Officially Full-On Dubber
Posts: 393
Threads: 21
Registered: January 23rd, 2007
Member Is Offline
Location: Townsville
Theme: UltimaBB Pro Blue ( Default )
|
| posted on May 29th, 2008 at 08:47 PM |
|
|
A few thoughts.
Check the fuel filter in the bottom of the tank as it could be blocked.
As a suggestion put a long piece of hose between the fuel pump outlet and the carby. Once hot and failing pull hose off carby and direct to a bucket
crank engine and check flow.
The problem sounds like an electrical issue or flooding...just check the fuel stop solenoid also in case the wire is loose causing HR to develop. As
mentioned check the plugs once it fails...all of them. Just a question when it fails doing it suddenly die or slowly fade out? More details on the
failing and immediate events before.
What my garage isn't messy........Well chaos is a form of order isn't it?
|
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on May 29th, 2008 at 10:33 PM |
|
|
I had a similar problem years ago
actually many times [not VW]
but the condenser used to fail..
once it cooled down it would go again until hot..
once i found this I used to have a spare condenser mounted ready to go...
and this happened lots of tiimes..
I had a loose connection to My coil a while back..
ended up throwing a good coil away... lol
Maybe the fuel cutoff is faulty...
I always throw the fuel tank filter away...
and place a filter under the tank...
Do You have the fuel filter in the engine bay???
NOT a good place...
LEE
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
esevwbits
Custom Title Time!
Posts: 1027
Threads: 143
Registered: June 17th, 2003
Member Is Offline
Theme: UltimaBB Streamlined2
Mood: alive!!
|
| posted on October 7th, 2009 at 10:45 AM |
|
|
id go with the coil. when they get hot, no spark! try a spare one!
|
|
|
aintgotitmusthaveit
A.k.a.: Nick
Officially Full-On Dubber
Posts: 295
Threads: 75
Registered: June 14th, 2006
Member Is Offline
Location: Melbourne
Theme: XMBX Pro Green
|
| posted on October 7th, 2009 at 11:19 PM |
|
|
Had this too. Mine turned out to be crap in the fuel line. It go sucked into A non STD elbow in the fuel line. When it got compacted (after driving a
while) I would splutter to a stop. As the fuel ran out I was getting lean bAckfires. When the carb stopped sucking the gunk relaxed allowing fuel to
partially flow again. I could restart eventuLly but it ran like a dog. Found this by checking a fuel line just after it stopped. It Nd the fuel filter
before the carb were empty. Hope this helps
|
|
|
