| [ Total Views: 1666 | Total Replies: 10 | Thread Id: 52374 ] |
|
|
 Menangler
A.k.a.: Dave Becker
Custom Title Time!
Posts: 1991
Threads: 309
Registered: August 26th, 2002
Member Is Offline
Location: South Coast NSW
Theme: UltimaBB Pro Blue ( Default )
|
| posted on May 19th, 2006 at 09:05 PM |
|
|
T3 Auto removal nightmare!
Has any one pulled an auto trans out of a T3 van using a trolley jack, car ramps and a block of wood? Its nasty, I hate it
I just did it again in my wifes '89 Caravelle for about the 5th time, in 5 years, what a bastard of a job, it doesn't get any easier, sliding off
the block of wood, just won't balance right on the jack, so bloody heavy, auto fluid all over the floor, CV greese in my hair, its just a nasty
job.
The torque converter decided to make bad weird noises during the week so I decided to change it for a spare one I had in the shed, and after finally
getting all the splines lined up and the converter sitting in the right position, fitting everything back in, its just a noisey as the one I pulled
out, so I have to do it all again tomorow!! anyone want to give me a hand?
I hate autos!:o
[ Edited on 19-5-2006 by Menangler ]
FAHRVERGNUGEN;
Description of a pleasurable sensation,
Experienced when a car and it's driver are in mutual harmony, A unique driving experience, Pleasure, Satisfaction,
A feeling experienced by Volkswagen Drivers.
 |
|
|
1303Steve
A.k.a.: Steve Carter
Scirocco Rare
Posts: 8650
Threads: 564
Registered: August 27th, 2002
Member Is Offline
Location: Sydney, NSW
Theme: UltimaBB Pro Blue ( Default )
Mood: Parrot Heading
|
| posted on May 20th, 2006 at 12:24 AM |
|
|
Hi
I feel your pain,I think you need to make a gearbox holder, below is the one I made for the G50. The G50 just didnt want to sit on a jack, so I made
holder that just slides into the top of my floor jack.
Steve
|
|
|
Volksaddict
Wolfsburg Wizard
Posts: 533
Threads: 102
Registered: December 25th, 2004
Member Is Offline
Location: Sawtell Mid North NSW
Theme: UltimaBB Pro Blue ( Default )
Mood: hooked
|
| posted on May 20th, 2006 at 01:42 PM |
|
|
Hope you werent swearing Dave |
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on May 20th, 2006 at 02:07 PM |
|
|
Just having ATF fluid everywhere is enough.....
specially made trolleys are the way to go.....
Best of Luck...
Looks like You will have to take the transmission to an Automatic repair specialist...
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
Menangler
A.k.a.: Dave Becker
Custom Title Time!
Posts: 1991
Threads: 309
Registered: August 26th, 2002
Member Is Offline
Location: South Coast NSW
Theme: UltimaBB Pro Blue ( Default )
|
| posted on May 20th, 2006 at 05:22 PM |
|
|
I was all set to make a jig this morning to pull the box out again, but before I started thought I would start the car up again and have a listen,
looking down throught the inspection hatch, the noise was coming from the bellhousing area, just the same as before, I slid under the car on a creaper
and had a listen, mmmmm noise seemed to be coming from the rear of the engine??? had a bit of a think..... bugger, it was the water pump all along,
took the trany out for nothing!! I pulled the belt off the pump to be sure, and it was quiet, so just had to change the water pump, that is another
bastard of a job in its self!!
But she is fixed and quiet again.
Not much time left to prepare the Beetle for the drags tomorrow, just chucked it on the trailer, will sort it out at the track in the morning.
[ Edited on 20-5-2006 by Menangler ]
FAHRVERGNUGEN;
Description of a pleasurable sensation,
Experienced when a car and it's driver are in mutual harmony, A unique driving experience, Pleasure, Satisfaction,
A feeling experienced by Volkswagen Drivers.
|
|
|
Kombi_Rescue
Wolfsburg Wizard
Posts: 440
Threads: 35
Registered: February 26th, 2005
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
Mood: DSK member
|
| posted on May 20th, 2006 at 06:42 PM |
|
|
the great escape dave ...mate the very worst transmission to remove from a vw is a T4 syncro....you always invent new words when pulling out one of
those babies....with factory tools i will add.....so life is not so bad just thin k every time you feel stuck.its not a T4 syncro cheers steve
|
|
|
Menangler
A.k.a.: Dave Becker
Custom Title Time!
Posts: 1991
Threads: 309
Registered: August 26th, 2002
Member Is Offline
Location: South Coast NSW
Theme: UltimaBB Pro Blue ( Default )
|
| posted on May 20th, 2006 at 07:27 PM |
|
|
I can imagine, just seems the newer a car is the harder it is to work on, give me an air cooler anyday
FAHRVERGNUGEN;
Description of a pleasurable sensation,
Experienced when a car and it's driver are in mutual harmony, A unique driving experience, Pleasure, Satisfaction,
A feeling experienced by Volkswagen Drivers.
|
|
|
seagull
Compulsive Aussie Vee Dubber
Posts: 4979
Threads: 752
Registered: December 25th, 2003
Member Is Offline
Location: PerthWA
Theme: UltimaBB Pro Blue ( Default )
|
| posted on May 22nd, 2006 at 01:56 AM |
|
|
I can see why many of these whent to the crusher
Looking for that special lady : PM me for coffee & cake
|
|
|
vwtyp2
Son of Jim - Creator of Good
Posts: 2504
Threads: 160
Registered: September 18th, 2003
Member Is Offline
Location: Hillcrest S.A.
Theme: UltimaBB Pro Blue ( Default )
Mood: over it
|
| posted on May 22nd, 2006 at 08:47 AM |
|
|
you don't have a spare auto trans for sale do you?
Most people seem normal, till you get to know them.
|
|
|
matara
Custom Title Time!
Posts: 1342
Threads: 255
Registered: August 25th, 2002
Member Is Offline
Location: Melrose Park, Sydney
Theme: UltimaBB Pro Grey
Mood: 356'd
|
| posted on May 22nd, 2006 at 11:28 AM |
|
|
Is that a G50 gearbox and Porsche 944 IRS arms Steve C? Nice..
|
|
|
1303Steve
A.k.a.: Steve Carter
Scirocco Rare
Posts: 8650
Threads: 564
Registered: August 27th, 2002
Member Is Offline
Location: Sydney, NSW
Theme: UltimaBB Pro Blue ( Default )
Mood: Parrot Heading
|
| posted on May 22nd, 2006 at 02:22 PM |
|
|
| Quote: | Originally
posted by matara
Is that a G50 gearbox and Porsche 944 IRS arms Steve C? Nice..
|
Hi Steve
That the new 1303 Im building, my 1973 1300 is in the background. The 944 arms are just a work of art.
Steve
|
|
|
