| [ Total Views: 675 | Total Replies: 5 | Thread Id: 91895 ] |
|
|
 gong_beetle
Learner Dubber
Posts: 3
Threads: 1
Registered: January 21st, 2011
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
|
| posted on August 1st, 2011 at 12:02 AM |
|
|
backfiring '70 1500
Hey guys,
I have 1970 1500 Beetle. It has been off the road for a couple of months. I went to start it up this afternoon as I will be moving it soon. It started
ok, but did not sound very healthy. A lot of backfiring, loss of power and just general roughness.
It had been serviced and was running really well just before going off the road. Any suggestions for possible cause of problem?
Thanks for any suggestions. |
|
|
Sides
A.k.a.: Dave Sidery
Veteran Volks Folk
Posts: 2220
Threads: 59
Registered: May 20th, 2007
Member Is Offline
Location: Brisbane
Theme: UltimaBB Pro Blue
Mood: Need... more... shed... time...
|
| posted on August 1st, 2011 at 08:41 AM |
|
|
Has the engine stayed nice and dry all that time, and not parked outside getting rained on etc ???
No water/moisture inside the dizzy cap ??? Or cracks in the cap for that matter ???
Most hassles with cars are electrical after all...
Assuming it really was running OK before it sat still, after above my next thought would be stale fuel. If the fuel you use has any ethanol component
in it (eg E10), well after a couple of months there's likely to be a fair bit of water in it too (the ethanol can cause it to absorb moisture out of
the air).
Plus potentially other gunk from things that aren't 100% compatible with ethanol... possibly fouling up jets in the carb. Maybe a flush of the fuel
system in order...
If it's not a fuel that includes ethanol, well still possibly gunk/crap in the fuel system, but I'd really be thinking electrical.
Volksy's are normally pretty hardy beasts... I've started engines that have sat for years, stale fuel and all and they've run like a clock within
just a few minutes.
VWDCQ vice pres & web dude - vwdcqinc.org.au
Join a car club - get car peeps
My toys
'70 Hillclimb Bug 'Jezebel' w/- Haltech EFI - http://bit.ly/VwTNtQ
'60 KG Coupe - resto kinda started
01 New Beetle - gf's car, but I turn the spanners |
|
|
gong_beetle
Learner Dubber
Posts: 3
Threads: 1
Registered: January 21st, 2011
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
|
| posted on August 1st, 2011 at 06:24 PM |
|
|
Thanks for the quick reply.
Have given it another 15-20 min run. Definitely less backfiring (still only with a push of the accelerator), but still has black smoke from the
exhaust, and when in gear, complete loss of power. Seems to be happy idling though.
I assure you it was running fine before I parked it. Checked the distributor cap for cracks or moisture to no avail.
I had been using premium fuel (vortex) before parking it. I would say it has sat no longer than 3 months. Would this fuel go stale so quickly.
Again, appreciate the quick reply, and any other suggestions would be fantastic. |
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on August 1st, 2011 at 11:16 PM |
|
|
| Quote: | Originally
posted by gong_beetle
Hey guys,
I have 1970 1500 Beetle. It has been off the road for a couple of months. I went to start it up this afternoon as I will be moving it soon. It started
ok, but did not sound very healthy. A lot of backfiring, loss of power and just general roughness.
It had been serviced and was running really well just before going off the road. Any suggestions for possible cause of problem?
Thanks for any suggestions.
|
Hi
My thoughts..
sounds like its out of tune...??
are the points nice & clean and gapped properly?
run a points file thru them about 10 times to clean them..
or... Your inlet manifold heater has rusted thru...
But black smoke usually means the fuel is too rich a mixture..
FLOODING of the carby...??
no easy fix I'm afraid.... more of a Find it then fix it...
LEE
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
gong_beetle
Learner Dubber
Posts: 3
Threads: 1
Registered: January 21st, 2011
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
|
| posted on August 2nd, 2011 at 10:13 PM |
|
|
Lee,
Thanks for your suggestions. Checked the points. Points gapped properly, not spotless, but certainly didn't need to much cleaning. Carb is fine too.
Think it might be time to see if a tune-up helps. Again, the only hesitation is that it was running so well before being parked.
Thanks again.
Rob |
|
|
pod
A.k.a.: paul mrvw061
Compulsive Aussie Vee Dubber
i`ve got to finish this thing one day
Posts: 4980
Threads: 145
Registered: December 28th, 2003
Member Is Offline
Location: campbelltown,nsw
Theme: UltimaBB Pro Yellow
Mood: could be better
|
| posted on August 3rd, 2011 at 01:51 AM |
|
|
when i got my bus going after sitting for years ,it would idle fine but not drive well,it turned out to be a blockage in the fuel supply(rusty tank)
,it would let enough through to idle but not enough to keep running at higher revs
|
|
|
