| [ Total Views: 2552 | Total Replies: 4 | Thread Id: 83720 ] |
|
|
 helbus
A.k.a.: Pete S
Super Administrator
Mad fabricator, paint and body
Posts: 7386
Threads: 312
Registered: September 1st, 2002
Member Is Offline
Location: In the garage chopping cars into bits
Theme: UltimaBB Pro Blue
Mood: In the thinking chair
|
| posted on May 17th, 2010 at 09:36 PM |
|
|
Victorian VASS Subaru EJ22 engine into Bus
I just had our bus finally inspected for VASS certification (Victoria only). The Suby engine has been in the bus for over 4 years now, and I don't
need to hear that I should have gotten the certification sooner.
Here are the facts.
1975 8 seater bus
Subaru EJ22 engine from 1992 Australian Subaru Liberty
Wheels 16x7 Alloy with 205/50/16 tyres
Lowered front beam
The factual results as done for Victorian approval.
Tests were done to have compliance with ADR's 27 and 28 and this is stated on the certificate
Engine has to pass emission test based on stock 1992 ECU and cat converter and was tested ok
Exhaust noise level test has to be quiet enough to pass and tested ok
Brake test was performed and the stock 1975 VW brakes were very good and passed well.
Rear engine cradle mount I had already installed and the Custom Vee Dub unit was passed.
Ground clearance under the engine had to be maintained and the CVD sump passed
Front suspension was lowered using Indian Automotive adjusters. The bump stop adjuster kit was also used and this all passed ok.
Wheel track was checked and had only increased 10mm over standard as listed in the owners manual and passed.
New retractable front seat belts and original ADR approved rear seatbelts were all approved. The rear seatbelts were checked to be in good working
order and condition.
The only items other than the actual modified items being engine, wheels and lowering. That were checked were as follows
Brake test, and brake fail light fitted (all stock 1975 passed)
All seatbelts in perfect working order. (retractables should be working as new)
Two speed wipers checked (stock)
Two speed demister fitted (ceramic electric heater under dash)
Presenting the vehicle in spotless condition fully detailed and cleaned and just serviced with new brake pads, shoes and discs. New windscreen just
fitted. All work on wiring looms, welding, brackets all very neat and painted. These things show that the vehicle is not just a rough slap bang
conversion by any means.
|
|
|
 mjwcookie
Seriously Crusin Dubber
Posts: 105
Threads: 57
Registered: March 21st, 2011
Member Is Offline
Location: Point Lonsdale, Vic
Theme: UltimaBB Pro Blue ( Default )
|
| posted on March 22nd, 2011 at 06:45 AM |
|
|
Any photos of the job.
Mark
Mark Wilson
78 bay window, 82 bay Westy. T3 Caravelle GL 89 on the road.
Now in Victoria.
|
|
|
Tonz Magonz
Officially Full-On Dubber
Posts: 201
Threads: 45
Registered: April 17th, 2005
Member Is Offline
Location: Sunny Melbourne
Theme: UltimaBB Pro Purple
|
| posted on March 28th, 2011 at 09:46 PM |
|
|
Wouldnt expect anything else but a clean bill of health after seeing your handiwork Pete....
Reassuring to know all the "i's are dotted and the "t"s are crossed, in the unlikely event of a mishap...
Cheers Tony
|
|
|
Brad
Wolfsburg Elder
Posts: 3764
Threads: 332
Registered: August 24th, 2002
Member Is Offline
Location: SE QLD, Mt Nebo
Theme: UltimaBB Pro Blue ( Default )
Mood: Manx Buggy Building
|
| posted on March 28th, 2011 at 10:17 PM |
|
|
Congrats good to see some facts in relation to what actually goes on. 
|
|
|
PASHN8
A.k.a.: Dino
Seriously Crusin Dubber
Posts: 198
Threads: 41
Registered: June 20th, 2003
Member Is Offline
Location: Melbourne, Australia.
Theme: UltimaBB Pro Blue ( Default )
|
| posted on June 22nd, 2011 at 02:58 PM |
|
|
Very interesting read, a question for those that know, if your vehicle wasn't fitted with retractable seatbelts from new, do you need to retrofit
them?
ie, do you need to retrofit things like 2-speed wipers and retractable belts to a car that never came with them?
|
|
|
