| [ Total Views: 814 | Total Replies: 7 | Thread Id: 95628 ] |
|
|
 shero
Learner Dubber
Posts: 2
Threads: 2
Registered: December 30th, 2010
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
|
 posted on March 1st, 2012 at 10:21 PM |
|
|
smokin kombi literally
Have noticed lately that my bus when i brake and decelerate to stop at lights smokes (blue so burning oil) up quite a bit and drops right off once
engine comes down to idle, are the valve guides worn so to speak or is it the valves themselves need re-seating, just done some maitenence and back
left spark plug is only one showing any form of build up, tappet clearence is in spec, want to know before i get a mechanic to over charge me . don't
know enough yet about my bus to go doing things i am unsure of and the like.. Help before i make a mechanic wealthier , ideas anyone or posts i can
look at to fault find. Some one help an idiot (learner i mean) |
|
|
vwjon
Fahrvergnugen
Posts: 914
Threads: 101
Registered: July 16th, 2006
Member Is Offline
Location: perth W.A
Theme: UltimaBB Pro Blue ( Default )
Mood: oily n thirsty
|
| posted on March 1st, 2012 at 10:26 PM |
|
|
valve guides, there is no oil involved in the valve seats, the only place the oil in that area can come from is the guides.
how is the van breathing? remove breather hose (put it in an empty milk carton) go for a spin, then see in theres any oil in the carton, your rings
might be giving you blow back (not as much fun as it sounds).
3 1959 cadillacs
1 musso
2 early notchbacks
2 split kombis
2 split panels
1 split ute
1 low light panel
1 ex-pmg bay
1 country buggy
1 beetle ute
1 14" syncro caravelle
1 16" syncro doka
1 golf cabrio
1 vw camper trailer
2 3meter bombs
|
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on March 2nd, 2012 at 12:01 AM |
|
|
| Quote: | Originally
posted by shero
Have noticed lately that my bus when i brake and decelerate to stop at lights smokes (blue so burning oil) up quite a bit and drops right off once
engine comes down to idle, are the valve guides worn so to speak or is it the valves themselves need re-seating, just done some maitenence and back
left spark plug is only one showing any form of build up, tappet clearence is in spec, want to know before i get a mechanic to over charge me . don't
know enough yet about my bus to go doing things i am unsure of and the like.. Help before i make a mechanic wealthier , ideas anyone or posts i can
look at to fault find. Some one help an idiot (learner i mean)
|
WE all started somewhere... lol
I was lucky I started driving beetles and type 3s in the 60s and 70s... when they weren't that old.,... lol
and I knew nothing at all....
its either piston rings or valve guides....
Valve seats just hold the compression in the cylinder basically..
You may have a broken piston ring which is letting oil past them into the cylinder...
or worn valve guides that are letting oil thru into the cylinder...
a compression tester is used on a spark plug hole, one cylinder at a time, and any bad readings means a problem..
so, You may have just one cylinder letting the oil into the cylinder and fouling the spark plug You mentioned..
it doesn't take long to take out the four spark plugs and test the compression of each cylinder... If He is a good old VW mechanic He may be able to
tell You the problem by listening
to your engine...
cheers
LEE
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
1916baja
Custom Title Time!
Posts: 1990
Threads: 176
Registered: September 20th, 2007
Member Is Offline
Location: Brisbane - Mt Gravatt
Theme: UltimaBB Pro Blue ( Default )
|
| posted on March 2nd, 2012 at 07:41 PM |
|
|
Where are you??? if you take it to a VW mechanic you wont be ripped off.
|
|
|
greedy53
Bishop of Volkswagenism
Posts: 3062
Threads: 468
Registered: March 4th, 2006
Member Is Offline
Location: camden nsw 2570
Theme: UltimaBB Pro Grey
Mood: strung out
|
| posted on March 3rd, 2012 at 11:12 AM |
|
|
a wild shot but it did happen to me
how is your break fluid i had my dam ute using a lot of fluid any how short story the leak in the master cylenderwas leaking into the booster so every
time i braked hard the dam stuff would run down into the booster so when it was full it would run along to the vacume feed and white smoke everywhere
but when i would gas it it stoped
|
|
|
vlad01
Compulsive Aussie Vee Dubber
Posts: 4270
Threads: 109
Registered: June 3rd, 2010
Member Is Offline
Location: Kyneton, VIC
Theme: UltimaBB Pro Blue ( Default )
Mood: Side ways
|
| posted on March 4th, 2012 at 07:58 AM |
|
|
blue smoke on decel generally is worn valve stems and guides.
71 notchback,
Past owner of, 70 NB, 73 SB and 72 FB TLE |
|
|
evsky
Seriously Crusin Dubber
Posts: 125
Threads: 24
Registered: September 27th, 2008
Member Is Offline
Location: Kincumber
Theme: UltimaBB Pro Blue ( Default )
|
| posted on March 6th, 2012 at 10:36 PM |
|
|
I had the same thing happen with my brake master cylinder as mentioned very smoky but the smell of burning brake fluid over oil was quite easy to
tell. Good luck.
|
|
|
ancientbugger
Custom Title Time!
Posts: 1986
Threads: 191
Registered: March 24th, 2004
Member Is Offline
Location: sunshine coast
Theme: UltimaBB Pro Yellow
|
| posted on March 7th, 2012 at 08:00 PM |
|
|
Before you start pulling the engine to bits, if you have the type 4 engine in your kombi then you could just have oil dripping from your rocker covers
onto the exhaust manifold as the exhaust on a type 4 exits underneath unlike the type 1 and you may only notice the smoke when slowing down. A couple
of new rocker cover gaskets could be all you need.
|
|
|
