| [ Total Views: 1089 | Total Replies: 8 | Thread Id: 111510 ] |
|
|
 KalgoorlieGreg
Seriously Crusin Dubber
Posts: 196
Threads: 36
Registered: August 21st, 2016
Member Is Offline
Location: Kalgoorlie, WA.
Theme: UltimaBB Pro Grey
Mood: Hey, look, a SQUIRREL!
|
| posted on September 2nd, 2016 at 06:05 PM |
|
|
Hot climate - extended sump?
Hi all,
Was wondering, here in Kal, it gets over 40C constantly during summer and would an extended sump help to control engine temps? More oil would help
disperse heat better?
I could be totally wrong and happy to be schooled!
|
|
|
 Bizarre
Super Moderator
The artist formerly known as blue74l
Posts: 12755
Threads: 731
Registered: August 25th, 2002
Member Is Offline
Location: Abbotsford, Sydney
Theme: UltimaBB Pro Blue ( Default )
|
| posted on September 2nd, 2016 at 08:45 PM |
|
|
More oil means it just takes longer to get hot
If anything an oil cooler is what you need / want
In / out on the oil pump is easiest
Make sure your tin is all in place and you tune correct
A stock motor driven normally should cope with a hot day
Futue te ipsum!!!
|
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on September 2nd, 2016 at 09:26 PM |
|
|
| Quote: | Originally
posted by KalgoorlieGreg
Hi all,
Was wondering, here in Kal, it gets over 40C constantly during summer and would an extended sump help to control engine temps? More oil would help
disperse heat better?
I could be totally wrong and happy to be schooled!
|
It doesn't make much difference to the oil temperature when the air temperature is 40c..
Greg with a beetle, I recommend having the top of the engine lid open using either the readily available alloy hinge STAND OFFS or I use the steel
bracket that is made from welded flat steel and can be installed or taken off in less than a minute..... so the top of your engine lid is open about
75mms approx.. and this does make the engine run cooler in the summer at 40c... with the air coming over the roof and into the engine bay... I have
vents in My engine lid so the hot air can also get out....
You will also see many early engine lids with two sets of vents in them, which was original in early beetle cabriolets, but all those You see will
have been made up. Now if Your engine is still a single port with original fan and housing, You can change to a later wider fan and housing plus the
wider [larger] oil cooler which will help keep Your engine much cooler than the originals. Do You have any pics of your engine?
My 1968 model beetle had no vents in the engine lid, but later ones did, and also was a single port engine [still is] but now has the later fan shroud
with new wider oil cooler and wider fan etc.. called a dog house fan shroud as the oil cooler sticks out from the back of the housing...
Make sure that the very hot air coming out under the engine cannot get back into the engine bay and getting sucked into the already hot oil cooler
The rubber seal around the engine bay needs to be in good condition.
Lee
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
modnrod
Fahrvergnugen
Posts: 978
Threads: 50
Registered: March 17th, 2011
Member Is Offline
Location: Midwest, Westoz.
Theme: UltimaBB Pro Blue
Mood: Old School Volksies!
|
| posted on September 2nd, 2016 at 11:02 PM |
|
|
Hi Greg.
Lo-40s for a few months in summer? Is that all? When does it get hot? 
Only joking man!
It's a different world with high temps and low humidity, it raises ALL temps as you know. A few tricks I've used over the years, in order of proven
effectiveness against CONTINUOUS running on the highway.........
1. A big ugly 80s whale tail. Makes a HUGE difference. Bloody ugly though, stand-offs are a pale substitute, but maybe prettier.
2. A water mister kit, like your patio has, aimed at the fan intake. Drops ALL temps, including oil (coz the surfaces don't transfer as much). Spray
for a few secs, wait a minute or 3, spray for a few secs, etc.
3. Extra oil cooler with a fan, but it needs cool airflow without any red dust or gravel thrown at the oil lines, so a bit tricky.
Best of all?
Keep the revs 3000-3500. If it still gets hot, then drive around at 75kph in 3rd, heaps less aero load but max air cooling.
Finally......park it up between 8am and 6pm maybe? 
Mine (hopefully......) will survive at 100kph up and down rolling hills in mid-hi 40s, into the usual 20kph headwinds, with less than 8% humidity,
while towing my dragbike on a 6x4 trailer if all the tricks work.
Hopefully.......
|
|
|
Bizarre
Super Moderator
The artist formerly known as blue74l
Posts: 12755
Threads: 731
Registered: August 25th, 2002
Member Is Offline
Location: Abbotsford, Sydney
Theme: UltimaBB Pro Blue ( Default )
|
| posted on September 3rd, 2016 at 10:06 AM |
|
|
if you are running a 1600 in an early beetle you WILL need more air in there
Hood Jax work a treat
http://forums.aussieveedubbers.com/viewtopic.php?tid=72556&page=1#pid691577
Futue te ipsum!!!
|
|
|
Newt
Wolfsburg Wizard
Posts: 478
Threads: 82
Registered: March 1st, 2008
Member Is Offline
Location: Perth
Theme: UltimaBB Pro Grey
Mood: Born 10 minutes late & never caught up.
|
| posted on September 6th, 2016 at 01:08 AM |
|
|
Guys
Im curious. Why do the 80s style whale tails make such a difference?
Ta
Newt
It is as it is - If you didnt enjoy today, you've missed the opportunity.
|
|
|
modnrod
Fahrvergnugen
Posts: 978
Threads: 50
Registered: March 17th, 2011
Member Is Offline
Location: Midwest, Westoz.
Theme: UltimaBB Pro Blue
Mood: Old School Volksies!
|
| posted on September 6th, 2016 at 05:53 AM |
|
|
Scientific method at work.
http://www.clubvw.org.au/oldart012
|
|
|
DasAuto77
Learner Dubber
Posts: 17
Threads: 4
Registered: April 17th, 2014
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
|
| posted on September 6th, 2016 at 09:20 AM |
|
|
I have actually fitted a scat deep sump to my 2l kombi some years back. I tow a 400kg trailer with sup board on roof to Byron over Christmas so
expect temps up to 35C. A deep sump does make a small difference and I am glad I fitted it. But it won't solve chronic overheating issues. And
yes, I have been running an accurate (at 100C) oil temp gauge for the last 5 years to compare and all tinware and muffler heat shield is in place.
http://forums.kombiclub.com/threads/high-capacity-oil-sumps.47261/
|
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on September 8th, 2016 at 08:39 PM |
|
|
| Quote: | Originally
posted by KalgoorlieGreg
Hi all,
Was wondering, here in Kal, it gets over 40C constantly during summer and would an extended sump help to control engine temps? More oil would help
disperse heat better?
I could be totally wrong and happy to be schooled!
|
They do help slightly.... and every degree that drops does help.
Worthwhile - Yes...
plus You can get a proper engine oil filter to sit in the extra sump.
LEE
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
