| [ Total Views: 976 | Total Replies: 11 | Thread Id: 102331 ] |
|
|
 aushardkore
Casual Dubber
Posts: 44
Threads: 10
Registered: May 22nd, 2013
Member Is Offline
Location: Canberra, AUS
Theme: UltimaBB Pro White
Mood: Insane.. always insane!
|
 posted on June 6th, 2013 at 01:18 PM |
|
|
leaky 68
68 bug ... Drivers side footwell is soaked around the pedals, passenger side isn't as bad, mostly wet around where the floor pan meets the front
panel... Anybody got any suggestions where to start? Found that the fresh air boxes drain hose wasn't attached... Fixed that, still leaks. Any common
places to check? And suggestions?
|
|
|
bajachris88
A.k.a.: Chris Leete
23 Windows of Awesome
The international telephone dialing code for Antarctica is 672.
Posts: 6661
Threads: 534
Registered: April 8th, 2005
Member Is Offline
Location: Tanah Merah, SE-QLD
Theme: UltimaBB Pro Blue ( Default )
Mood: A bee bit ma' bottom, now ma' bottom's big!
|
| posted on June 6th, 2013 at 02:28 PM |
|
|
Was this leak occuring during driving or over night?
(ô_!_/ô) (ô_!_/ô)
69' baja: kombi box, thing spindles, irs, disc front, type 3 rear drums, 2 inch lift kit, 31x10 rears. 
New engine in process: 94mm p&bs, 74mm C/w chomol Crank, 35.5x39 SP heads, turbo. Wierd combo, hopeful torque monsta! |
|
|
aushardkore
Casual Dubber
Posts: 44
Threads: 10
Registered: May 22nd, 2013
Member Is Offline
Location: Canberra, AUS
Theme: UltimaBB Pro White
Mood: Insane.. always insane!
|
| posted on June 6th, 2013 at 02:35 PM |
|
|
Overnight and we had some pretty good rain over 2 days. I also wet it down with the hose in an attempt to spot leaks... Didn't work.
|
|
|
shokwave2
A.k.a.: Matt Hamilton
Officially Full-On Dubber
Posts: 289
Threads: 28
Registered: March 7th, 2010
Member Is Offline
Theme: UltimaBB Psyche Blue
|
| posted on June 6th, 2013 at 07:48 PM |
|
|
Check for water in the tunnel. I had the same problem a few years ago. Water spraying up from the road and puddles was entering the tunnel from
underneath car, near front of transmission. Water would exit out where the pedal cluster enters the tunnel every time I turned left. Took me while to
figure it out. Take out carpet/mats and take it for a few sharp left handers.
|
|
|
Kent
Casual Dubber
Posts: 35
Threads: 13
Registered: February 17th, 2013
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
|
| posted on June 6th, 2013 at 10:35 PM |
|
|
i had this issue, and it was in my weak windscreen rubber ! have a look at the condidtion of your windscreen rubbers, even try spraying the hose just
on the window and have a look.
|
|
|
pod
A.k.a.: paul mrvw061
Compulsive Aussie Vee Dubber
i`ve got to finish this thing one day
Posts: 4980
Threads: 145
Registered: December 28th, 2003
Member Is Offline
Location: campbelltown,nsw
Theme: UltimaBB Pro Yellow
Mood: could be better
|
| posted on June 6th, 2013 at 10:47 PM |
|
|
i had it on the passenger side , eventually found out it was leaking in through the car aerial 
|
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on June 7th, 2013 at 01:29 AM |
|
|
| Quote: | Originally
posted by aushardkore
68 bug ... Drivers side footwell is soaked around the pedals, passenger side isn't as bad, mostly wet around where the floor pan meets the front
panel... Anybody got any suggestions where to start? Found that the fresh air boxes drain hose wasn't attached... Fixed that, still leaks. Any common
places to check? And suggestions?
|
check under the bonnet as there are holes for water to escape under the windscreen rubber in the corners [also under rear window]
You can get some black silicon [silastic] and squeeze under the windscreen rubber... You don't need much except at teh bottom corners and where the
wipers come out..
and naturally if any cracks in the rubber..
maybe across the top... depending on the age of the rubber..
cheers
LEE
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
aushardkore
Casual Dubber
Posts: 44
Threads: 10
Registered: May 22nd, 2013
Member Is Offline
Location: Canberra, AUS
Theme: UltimaBB Pro White
Mood: Insane.. always insane!
|
| posted on June 7th, 2013 at 02:03 PM |
|
|
Leaking through both bottom corners, silastic last night, wet floor this morning... But not asbad. Strong fuel smell too. Checked all the fuel lines
on top and the bottom.. no leaks.. where does it go from under the tank?
|
|
|
sander288
Custom Title Time!
"Bolt-on Master"
Posts: 1404
Threads: 183
Registered: August 26th, 2008
Member Is Offline
Location: Norman Park, QLD
Theme: UltimaBB Pro Blue ( Default )
Mood: This is my bug. There are many others like it, but this one is mine.
|
| posted on June 7th, 2013 at 02:17 PM |
|
|
http://www.vwdcqinc.org.au/insideabug-insideabug_63type1
|
|
|
aushardkore
Casual Dubber
Posts: 44
Threads: 10
Registered: May 22nd, 2013
Member Is Offline
Location: Canberra, AUS
Theme: UltimaBB Pro White
Mood: Insane.. always insane!
|
| posted on June 7th, 2013 at 02:33 PM |
|
|
Excellent.... Can I get in there without cutting?
|
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on June 8th, 2013 at 12:48 AM |
|
|
| Quote: | Originally
posted by aushardkore
Leaking through both bottom corners, silastic last night, wet floor this morning... But not asbad. Strong fuel smell too. Checked all the fuel lines
on top and the bottom.. no leaks.. where does it go from under the tank?
|
the fuel tank breather goes from the tank up over the dash into a long white container then hose back to the left hand side of the spare wheel and
thru the body underneath..
There is also a larger hose next to the filler that lets air into the tank while its getting filled with fuel..
ALL those cotton covered hoses v small small medium and large all need to be replaced with new hose... cotton covered or plain black oil hose.. that
cotton covered hose cracks and lets the fumes out of the hose... if fuel gets to the split hose, it will spill out.. difficult to see the splits..
best to chuck it all.. very common,,,
the fuel filler hose does split into layers and ends up leaking too..
fumes or petrol if the tank is full
LEE
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
aushardkore
Casual Dubber
Posts: 44
Threads: 10
Registered: May 22nd, 2013
Member Is Offline
Location: Canberra, AUS
Theme: UltimaBB Pro White
Mood: Insane.. always insane!
|
| posted on June 8th, 2013 at 02:33 PM |
|
|
Lee your a champ. I've just ripped them all out and sure enough, cracked to hell. I'm a massive car enthusiast, but a bit lost on the old vw. Tend
to second guess myself a lot. You've proved to be an absolute database of good info mate. Thanks again. And the rest on here, bloody good info and
helpful too. Fixed my problems  thanks heaps... Happy dubber 
|
|
|
