| [ Total Views: 545 | Total Replies: 8 | Thread Id: 102550 ] |
|
|
 gotthebug65
Slammed & Awesome Dubber
Posts: 81
Threads: 31
Registered: April 8th, 2012
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
Mood: ok
|
| posted on June 25th, 2013 at 04:36 PM |
|
|
beetle starts then stops
Hi all im tinking i might have a fuel pump issue as my beetle will start, run perfectly, then stop and in paticular when i go to move it a few mins in
to running.
It feels like it starves and then stops under load; brings it on i think.
choke is adjusted well and opens fine
anyone else had this issue or any other ideas?
|
|
|
lohoon
Wolfsburg Wizard
Posts: 466
Threads: 67
Registered: September 5th, 2002
Member Is Offline
Location: muswellbrook
Theme: UltimaBB Pro Yellow
|
| posted on June 25th, 2013 at 05:51 PM |
|
|
Check your fuel filter if you have one. Also shine a torch lite under the front wheel arch. Look for the fuel line where it connects to the tank. I
had one kink itself over and stop the majority of fuel.
A few ideas.
|
|
|
 Bizarre
Super Moderator
The artist formerly known as blue74l
Posts: 12757
Threads: 732
Registered: August 25th, 2002
Member Is Offline
Location: Abbotsford, Sydney
Theme: UltimaBB Pro Blue ( Default )
|
| posted on June 25th, 2013 at 06:48 PM |
|
|
If it was fuel it would do it even when idling?
Just try idling for a while, enough to empty the bowl.
if it can idle then it isnt pump
How long has it been doing this??
I am assuming this is a new fault??
or has it never worked and its a new car??
Futue te ipsum!!!
|
|
|
donn
Wolfsburg Elder
Posts: 3515
Threads: 428
Registered: November 30th, 2005
Member Is Offline
Location: NEWCASTLE NSW
Theme: UltimaBB Pro Blue
Mood: LAID BACK AND CONFUSED
|
| posted on June 25th, 2013 at 08:20 PM |
|
|
I had a similar problem, the car would sit and idle all day if needed but when I went to move off it would stop, turned out to be an almost totaly
blocked fuel filter.
I dream of a day when a chicken can cross a road without being asked for it's motive!
|
|
|
gotthebug65
Slammed & Awesome Dubber
Posts: 81
Threads: 31
Registered: April 8th, 2012
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
Mood: ok
|
| posted on June 25th, 2013 at 08:49 PM |
|
|
| Quote: | Originally
posted by Bizarre
If it was fuel it would do it even when idling?
Just try idling for a while, enough to empty the bowl.
if it can idle then it isnt pump
How long has it been doing this??
I am assuming this is a new fault??
or has it never worked and its a new car??
|
yeah seems to idle ok can idle as long as it wants just when i start to put it under load it dies slowly like within 5 seconds.
|
|
|
gotthebug65
Slammed & Awesome Dubber
Posts: 81
Threads: 31
Registered: April 8th, 2012
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
Mood: ok
|
| posted on June 25th, 2013 at 08:50 PM |
|
|
| Quote: | Originally
posted by donn
I had a similar problem, the car would sit and idle all day if needed but when I went to move off it would stop, turned out to be an almost totaly
blocked fuel filter.
|
yeah going to have a good look at the fule line tommorrow and change filter...
|
|
|
bajachris88
A.k.a.: Chris Leete
23 Windows of Awesome
The international telephone dialing code for Antarctica is 672.
Posts: 6661
Threads: 534
Registered: April 8th, 2005
Member Is Offline
Location: Tanah Merah, SE-QLD
Theme: UltimaBB Pro Blue ( Default )
Mood: A bee bit ma' bottom, now ma' bottom's big!
|
| posted on June 26th, 2013 at 08:27 AM |
|
|
does the accelerator pump work? take off your air filter, look down the carb (with the car off) if you pump the throttle with you hand, do you see a
good squirt of fuel going down in there?
Idling proves your idle jet works 
(ô_!_/ô) (ô_!_/ô)
69' baja: kombi box, thing spindles, irs, disc front, type 3 rear drums, 2 inch lift kit, 31x10 rears.
New engine in process: 94mm p&bs, 74mm C/w chomol Crank, 35.5x39 SP heads, turbo. Wierd combo, hopeful torque monsta! |
|
|
gotthebug65
Slammed & Awesome Dubber
Posts: 81
Threads: 31
Registered: April 8th, 2012
Member Is Offline
Theme: UltimaBB Pro Blue ( Default )
Mood: ok
|
| posted on June 26th, 2013 at 06:27 PM |
|
|
fuel filter was filthy
tank is filthy
going to buy some ne fuel line its old and near crumbling lol
any tips for cleaning the tank out?
cheers and beers allround for all the replies so far
|
|
|
68AutoBug
A.k.a.: Lee Noonan
Aircooled Master
Beetle Restorer - Experience over 138% - YIKES --
Posts: 11654
Threads: 449
Registered: August 31st, 2002
Member Is Offline
Location: SCONE in UPPER HUNTER VALLEY NSW
Theme: UltimaBB Pro Yellow
Mood: Really Mentally Ill - all of the time -
|
| posted on June 27th, 2013 at 02:50 PM |
|
|
Hi
You can probably take the tank out of the car, fairly easy, and replace the hose under the tank.. use a piece longer than You need so it doesn't
crimp closed.. seen that happen many times.. lol
I have two fuel filters under My fuel tank..
You could use many cleaners on the market to clean inside the tank..
biggest problem is rust in the tank from any water..
You can also get special paint/coating to paint inside the tank..
if You wish.. but if its clean after you have cleaned it..
I like the el cheapo foaming $2-3 foaming degreaser spray cans..
Just spray wait about 30 seconds and hose off...
cheers
LEE
- [size=4]Helping keep Air Cooled VWs on the road - location: SCONE in the Upper Hunter Valley - Northern NSW 320 kms NNW of SYDNEY--- [/size]
|
|
|
