Board Logo
Go To Bottom

Printable Version  
[ Total Views: 969 | Total Replies: 2 | Thread Id: 111122 ]
Author: Subject:  1600dp in 1200sp trans???? Help...
Memberdanza85
Learner Dubber
*


No Avatar


Posts: 19
Threads: 10
Registered: November 3rd, 2014
Member Is Offline

Theme: UltimaBB Pro Blue ( Default )

posted on June 12th, 2016 at 01:43 PM
1600dp in 1200sp trans???? Help...


So I know this topic would have been covered a million and one times. I have done some research. As far as I can see the block itself bolts up fine. The only issue is the flywheel. Now either grind out trans or replace??

My question is. I have a complete 1200 incl flywheel and clutch. Can I swap that into 1600dp? Hense removing and issues? Still running 6v starter on 12v system..


Thanks in advance...

😄
Memberbevoracing
A.k.a.: Tony Beven
Officially Full-On Dubber
***


Avatar


Posts: 321
Threads: 35
Registered: January 18th, 2009
Member Is Offline

Location: Mount Pleasant SA
Theme: UltimaBB Vintage
Mood: Leaning against the shed wall !.

posted on June 12th, 2016 at 06:37 PM



I Danza
Yep, it’s been talked about a lot over the years.
http://forums.aussieveedubbers.com/viewtopic.php?tid=109790 
http://forums.aussieveedubbers.com/viewtopic.php?tid=111093&page=1#pid102...
I presume you want to put a Twin Port 1600 in an older 1200 trans?
The 1200 engine you have will almost certainly have a 180mm clutch and flywheel on it. That isn’t big enough for a 1600, it will slip almost immediately. You need a 200mm clutch and a flywheel to suit.
They come in 2 basic sorts :-
- There was a transitional 200mm with a 6 volt ring gear on it that could be used with a 6 volt starter. They are quite rare.
- There is a 1600 one with a 12 volt ring gear requiring a 12 volt starter. You can’t use a 6V starter on a 12V flywheel or vice versa. You have one of those.
There’s some other issue with flywheels with or without “O” Rings but you can get past that.
Using a 12 volt flywheel will require a small amount of clearancing in the bell housing, a “12V starter to 6V gearbox” starter bush (6V outer with the smaller 12V inside diameter), and a pressure plate with the thrust face in the center to suit the gearbox without the thrust bearing guide tube. The one you have on the 1600 probably only has the bare fingers in the center.
So, after you get all that together, you’re on the road, same as thousands of other early beetles with later engines.
Good luck & enjoy.
Cheers
Tony




Country Buggy King & Link Pin Overhauls, Type 1 & 2 King Pins, General Machining.
http://forums.aussieveedubbers.com/viewtopic.php?tid=74138 
My car is KO813
Memberdanza85
Learner Dubber
*


No Avatar


Posts: 19
Threads: 10
Registered: November 3rd, 2014
Member Is Offline

Theme: UltimaBB Pro Blue ( Default )

posted on June 15th, 2016 at 08:21 AM



Thanks Tony! Well informed now. Your a champ..


  Go To Top


Powered by GaiaBB, © 2011 The GaiaBB Group


[ Queries: 40 ] [ PHP: 16.3% - SQL: 83.7% ]
#Duration:Query:
1.0.00024700SELECT * FROM ubb_settings
2.0.00021005SELECT moderator FROM ubb_forums WHERE moderator != ''
3.0.00018811SELECT DISTINCT uid FROM ubb_members WHERE username = 'BUGBOY'
4.0.00014806SELECT DISTINCT uid FROM ubb_members WHERE username = 'MickH'
5.0.00014591SELECT DISTINCT uid FROM ubb_members WHERE username = 'barls'
6.0.00013900SELECT DISTINCT uid FROM ubb_members WHERE username = 'vanderaj'
7.0.00013614SELECT DISTINCT uid FROM ubb_members WHERE username = 'Cam'
8.0.00015807SELECT DISTINCT uid FROM ubb_members WHERE username = 'vw54'
9.0.00013494SELECT DISTINCT uid FROM ubb_members WHERE username = 'SuperOwen'
10.0.00013995SELECT DISTINCT uid FROM ubb_members WHERE username = 'helbus'
11.0.00012994SELECT DISTINCT uid FROM ubb_members WHERE username = '65busser'
12.0.00014114SELECT DISTINCT uid FROM ubb_members WHERE username = 'Baja Wes'
13.0.00012898SELECT DISTINCT uid FROM ubb_members WHERE username = 'Dasdubber'
14.0.00015998SELECT DISTINCT uid FROM ubb_members WHERE username = 'MISS VDUB'
15.0.00056601SELECT LENGTH(robot_string) AS strlen, robot_string, robot_fullname FROM ubb_robots ORDER BY strlen DESC
16.0.00021911SELECT f.fid, f.theme FROM ubb_forums f, ubb_threads t WHERE f.fid = t.fid AND t.tid = '111122'
17.0.00027108DELETE FROM ubb_whosonline WHERE ip = '3.235.184.215' && (username = 'xguest123' OR username = 'xrobot123' OR username = 'Anonymous') OR time < '1623894063'
18.0.00016403INSERT INTO ubb_whosonline (username, ip, time, location, invisible, robotname) VALUES ('xguest123', '3.235.184.215', LPAD('1623894663', '15', '0'), '/viewtopic.php?tid=111122', '0', '')
19.0.00015712DELETE FROM ubb_guestcount WHERE ((ipaddress = '3.235.184.215') OR (onlinetime < '1623808263'))
20.0.00009418DELETE FROM ubb_robotcount WHERE ((ipaddress = '3.235.184.215') OR (onlinetime < '1623808263'))
21.0.00007987INSERT INTO ubb_guestcount (ipaddress, onlinetime) VALUES ('3.235.184.215', '1623894663')
22.0.00016093SELECT * FROM ubb_themes WHERE themeid = '1'
23.0.00010300SELECT * FROM ubb_pluglinks ORDER BY displayorder ASC
24.0.00013304SELECT id FROM ubb_banned WHERE ((ip1 = '3' OR ip1 = '-1') AND (ip2 = '235' OR ip2 = '-1') AND (ip3 = '184' OR ip3 = '-1') AND (ip4 = '215' OR ip4 = '-1')) AND NOT (ip1 = '-1' AND ip2 = '-1' AND ip3 = '-1' AND ip4 = '-1')
25.0.00043607SELECT fid, type, name, fup, status, private, userlist, password FROM ubb_forums WHERE private != '5' AND private != '3' AND private != '2' AND userlist = '' AND password = '' AND status = 'on' ORDER BY displayorder
26.0.00012207SELECT themeid, name FROM ubb_themes
27.0.00087810SELECT name, template FROM ubb_templates WHERE name IN ('functions_bbcode', 'functions_bbcodeinsert', 'functions_smilieinsert_smilie', 'functions_smilieinsert', 'viewtopic_reply', 'viewtopic_quickreply', 'viewtopic', 'viewtopic_invalid', 'viewtopic_modoptions', 'viewtopic_newpoll', 'viewtopic_newtopic', 'viewtopic_poll_options_view', 'viewtopic_poll_options', 'viewtopic_poll_submitbutton', 'viewtopic_poll', 'viewtopic_post', 'viewtopic_post_email', 'viewtopic_post_site', 'viewtopic_post_icq', 'viewtopic_post_aim', 'viewtopic_post_msn', 'viewtopic_post_yahoo', 'viewtopic_post_search', 'viewtopic_post_profile', 'viewtopic_post_pm', 'viewtopic_post_ip', 'viewtopic_post_repquote', 'viewtopic_post_report', 'viewtopic_post_edit', 'viewtopic_post_delete', 'viewtopic_post_attachmentimage', 'viewtopic_post_attachment', 'viewtopic_post_attach_noborder', 'viewtopic_post_attimg_noborder', 'viewtopic_post_sig', 'viewtopic_post_nosig', 'viewtopic_printable', 'viewtopic_printable_row', 'viewtopic_multipage', 'viewtopic_post_attachment_none', 'viewforum_rules', 'viewtopic_post_blog', 'viewtopic_post_rpg', 'viewforum_mpn_info', 'viewtopic_next_prev_links', 'viewtopic_captcha', 'css', 'error', 'footer', 'footer_querynum', 'footer_load', 'footer_phpsql', 'footer_totaltime', 'header', 'message', 'meta_tags', 'shadow', 'shadow2')
28.0.00022101SELECT t.tid, t.fid, t.subject, t.views, t.replies, t.closed, t.topped, l.uid as lp_uid, l.username as lp_user, l.dateline as lp_dateline, l.pid as lp_pid FROM ubb_threads t LEFT JOIN ubb_lastposts l ON l.tid = t.tid WHERE t.tid = '111122'
29.0.00015283SELECT * FROM ubb_forums WHERE fid='57' AND status='on'
30.0.00012493SELECT code, url FROM ubb_smilies WHERE type = 'smiley'
31.0.00007391SELECT find, replace1 FROM ubb_words
32.0.00013113SELECT id, title, posts, stars, allowavatars, avatarrank FROM ubb_ranks
33.0.00014305UPDATE ubb_threads SET views = views+1 WHERE tid = '111122' LIMIT 1
34.0.00017786SELECT COUNT(pid) FROM ubb_posts WHERE tid = '111122'
35.0.00897098SELECT t.tid as t_tid FROM ubb_threads t LEFT JOIN ubb_threads o ON o.tid = 111122 LEFT JOIN ubb_lastposts l ON l.tid = t.tid LEFT JOIN ubb_lastposts x ON x.tid = o.tid WHERE l.dateline < x.dateline AND t.fid = '57' ORDER BY l.dateline DESC LIMIT 1
36.0.00816107SELECT t.tid as t_tid FROM ubb_threads t LEFT JOIN ubb_threads o ON o.tid = 111122 LEFT JOIN ubb_lastposts l ON l.tid = t.tid LEFT JOIN ubb_lastposts x ON x.tid = o.tid WHERE l.dateline > x.dateline AND t.fid = '57' ORDER BY l.dateline ASC LIMIT 1
37.0.00018597SELECT vote_id FROM ubb_vote_desc WHERE topic_id = '111122'
38.0.00016689SELECT pid FROM ubb_posts WHERE tid = '111122' ORDER BY pid LIMIT 0, 30
39.0.00016785SELECT * FROM ubb_attachments WHERE pid IN('1027137', '1027145', '1027207')
40.0.00044394SELECT p.*, m.*,w.time FROM ubb_posts p LEFT JOIN ubb_members m ON m.username = p.author LEFT JOIN ubb_whosonline w ON p.author = w.username WHERE p.fid = '57' AND p.tid = '111122' ORDER BY p.pid ASC LIMIT 0, 30